p­Nitrochlorobenzene

IDLH Documentation
CAS number: 100­00­5

NIOSH REL: None established; NIOSH considers p­nitrochlorobenzene to be a potential occupational carcinogen as defined by the OSHA carcinogen policy [29 CFR 1990] that may be absorbed through the skin.

Current OSHA PEL: 1 mg/m3 TWA [skin]

1989 OSHA PEL: Same as current PEL

1993-1994 ACGIH TLV: 0.64 mg/m3 (0.1 ppm) TWA [skin]

Description of substance: Yellow, crystalline solid with a sweet odor.

LEL: . . . Unknown

Original (SCP) IDLH: 1,000 mg/m3

Basis for original (SCP) IDLH: No data on acute inhalation toxicity are available on which to base an IDLH for p­nitrochlorobenzene. The chosen IDLH, therefore, is based on an analogy with nitrobenzene, which has an IDLH of 200 ppm. [Note: A concentration of 200 ppm nitrobenzene is equivalent to about 1,000 mg/m3 p­nitrochlorobenzene.]

Short-term exposure guidelines: None developed

ACUTE TOXICITY DATA:

Lethal concentration data:

Species
Reference
LC50
LCLo
Time
Adjusted 0.5-hr

LC (CF)
Derived value
CatWatrous & Schultz 1950
164 mg/m3
-----
7 hr
393 mg/m3 (2.4)
39 mg/m3

Lethal dose data:

Species
Reference
Route
LD50

(mg/kg)
LDLo

(mg/kg)
Adjusted LD
Derived value
RatBack et al. 1972
oral
812
-----
5,684 mg/m3
568 mg/m3
MouseBack et al. 1972
oral
1,414
-----
9,898 mg/m3
990 mg/m3
MouseIzmerov et al. 1982
oral
440
-----
3,080 mg/m3
308 mg/m3
RatSziza & Magos 1959
oral
420
-----
2,940 mg/m3
294 mg/m3

Other animal data: Exposures of cats and guinea pigs to 87 mg/m3 for 8 hours/day for 6 weeks resulted in methemoglobinemia and slight anemia [Watrous and Schultz 1950].

Human data: Workers exposed intermittently for 0.5 to 1 hour over many months to concentrations ranging from 7 to 400 mg/m3 (average of 90 mg/m3) had only vague complaints of tiredness, loss of appetite, headache, and afternoon fatigue [Watrous and Schultz 1950]. Because of the strong and disagreeable odor, these workers voluntarily wore respiratory protection when exposed to the higher concentrations [Watrous and Schultz 1950].

Revised IDLH: 100 mg/m3

Basis for revised IDLH: The revised IDLH for p­nitrochlorobenzene is 100 mg/m3 based on subchronic inhalation toxicity data in workers [Watrous and Schultz 1950] and animals [Watrous and Schultz 1950]. This may be a conservative value due to the lack of relevant acute toxicity data for workers exposed to concentrations above 100 mg/m3. [Note: NIOSH recommends as part of its carcinogen policy that the "most protective" respirators be worn for p­nitrochlorobenzene at any detectable concentration.]

REFERENCES:

1. Back KC, Thomas AA, MacEwen JD [1972]. Reclassification of materials listed as transportation health hazards. Wright­Patterson Air Force Base, OH: 6570th Aerospace Medical Research Laboratory, Report No. TSA­20­72­3, pp. A­270 to A­271.

2. Izmerov NF, Sanotsky IV, Sidorov KK [1982]. Toxicometric parameters of industrial toxic chemicals under single exposure. Moscow, Russia: Centre of International Projects, GKNT, p. 92.

3. Sziza M, Magos I [1959]. Toxikologische untersuchung einiger in der ungarischen industrie zur anwendung gelangenden aromatischen nitroverbindungen. Arch Gewerbepath Gewerbehyg 17:217­226 (in German).

4. Watrous RM, Schultz HN [1950]. Cyclohexylamine, p­chloronitrobenzene, 2­aminopyridine: toxic effects in industrial use. Ind Med Surg 19:317­320.
Go back to the Documentation for Immediately Dangerous To Life or Health Concentrations (IDLHs)