NIOSH REL: None established; NIOSH considers methoxychlor to be a potential occupational carcinogen as defined by the OSHA carcinogen policy [29 CFR 1990].
Current OSHA PEL: 15 mg/m3 TWA
1989 OSHA PEL: 10 mg/m3 TWA
19931994 ACGIH TLV: 10 mg/m3 TWA
Description of substance: Colorless to lightyellow crystals with a slight, fruity odor.
LEL: . . Unknown
Original (SCP) IDLH*: No Evidence [*Note: "Effective" IDLH = 7,500 mg/m3 -- see discussion below.]
Basis for original (SCP) IDLH: ACGIH  stated that methoxychlor has a very low toxicity. The available toxicological data indicate that an acute exposure to a high concentration of methoxychlor would not result in death or in any irreversible health effects. For this draft technical standard, therefore, respirators have been selected on the basis of the assigned protection factor afforded by each device. However, for some particulate substances for which no evidence of an IDLH exists, the determination of allowable respiratory protection based on protection factors may result in the assignment of respirators for concentrations that are not likely to be encountered in the occupational environment. Therefore, for all such particulate substances, it has been arbitrarily determined that only the "most protective" respirators are permitted for use in concentrations exceeding 500 ´ the OSHA PEL (500 ´ 15 mg/m3 is 7,500 mg/m3).
Shortterm exposure guidelines: None developed
ACUTE TOXICITY DATA:
Lethal dose data:
|Mouse||Coats et al. 1977|
|Rabbit||Kenaga & Morgan 1978|
Human data: It has been reported that 6,430 mg/kg
is the estimated fatal oral dose [AAPCO 1966]. [Note: An oral
dose of 6,430 mg/kg is equivalent to a worker being exposed
to about 300,000 mg/m3 for 30 minutes, assuming
a breathing rate of 50 liters per minute and 100% absorption.]
|Revised IDLH: 5,000 mg/m3
Basis for revised IDLH: The available toxicological data contain no evidence that an acute exposure to a high concentration of methoxychlor would impede escape or cause any irreversible health effects within 30 minutes. However, the revised IDLH for methoxychlor is 5,000 mg/m3 based on being 500 times the OSHA PEL of 10 mg/m3 (500 is an assigned protection factor for respirators and was used arbitrarily during the Standards Completion Program for deciding when the "most protective" respirators should be used for particulates). [Note: NIOSH recommends as part of its carcinogen policy that the "most protective" respirators be worn for methoxychlor at any detectable concentration.]
1. AAPCO . Pesticide chemicals official compendium. Topeka, KS: Association of the American Pesticide Control Officials, Inc., p. 750.
2. ACGIH . Methoxychlor (2,2bispmethoxy phenyl1,1,1trichloroethane). In: Documentation of the threshold limit values for substances in workroom air. 3rd ed. Cincinnati, OH: American Conference of Governmental Industrial Hygienists, pp. 152153.
3. CDC . Clinical memoranda on economic poisons. Atlanta, GA: Communicable Disease Center, Bureau of State Services, Public Health Service, U.S. Department of Health, Education, and Welfare, Public Health Service Publication No. 476, pp. 3338.
4. Coats JR, Metcalf RL, Kapoor IP . Effective DDT analogues with altered aliphatic moieties. Isobutanes and chloropropanes. J Agri Food Chem 25:859868.
5. Kenaga EE, Morgan RW . Commercial and experimental organic insecticides (1978 revision). Entomological Society of America Special Publication 781:16. Go back to the Documentation for Immediately Dangerous To Life or Health Concentrations (IDLHs)