International Chemical Safety Cards

DIETHYLENE GLYCOL DIETHYL ETHER

ICSC: 1151

1,1'-Oxybis(2-ethoxy-ethane)
Diethyl carbitol
bis(2-Ethoxyethyl) ether
DEGDEE
Ethyl diglyme
C₈H₁₈O₃ / (C₂H₅CH₂CH₂)₂O
Molecular mass: 162.2
ICSC # 1151
CAS # 112-36-7
RTECS # KN3160000
April 19, 2004 Peer reviewed

TYPES OF HAZARD/ EXPOSURE	ACUTE HAZARDS/ SYMPTOMS	PREVENTION	FIRST AID/ FIRE FIGHTING
FIRE	Combustible.	NO open flames.	Powder, alcohol-resistant foam, water spray, carbon dioxide.
EXPLOSION	Above 71°C explosive vapour/air mixtures may be formed.	Above 71°C use a closed system, ventilation.

EXPOSURE
•INHALATION		Ventilation.	Fresh air, rest.
•SKIN	Redness. Dry skin.	Protective gloves.	Remove contaminated clothes. Rinse skin with plenty of water or shower.
•EYES	Redness.	Safety spectacles.	First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then take to a doctor.
•INGESTION		Do not eat, drink, or smoke during work.	Rinse mouth.

SPILLAGE DISPOSAL

STORAGE

PACKAGING & LABELLING

Collect leaking and spilled liquid in sealable containers as far as possible. Wash away remainder with plenty of water.

Separated from strong oxidants. Ventilation along the floor.

R:
S:

SEE IMPORTANT INFORMATION ON BACK

ICSC: 1151

Prepared in the context of cooperation between the International Programme on Chemical Safety & the Commission of the European Communities (C) IPCS CEC 1994. No modifications to the International version have been made except to add the OSHA PELs, NIOSH RELs and NIOSH IDLH values.

International Chemical Safety Cards

DIETHYLENE GLYCOL DIETHYL ETHER

ICSC: 1151

I

M

P

O

R

T

A

N

T

D

A

T

A

PHYSICAL STATE; APPEARANCE:
COLOURLESS VISCOUS LIQUID

PHYSICAL DANGERS:

CHEMICAL DANGERS:
The substance can presumably form explosive peroxides. Reacts with strong oxidants.

OCCUPATIONAL EXPOSURE LIMITS:
TLV not established.
MAK not established.

ROUTES OF EXPOSURE:

INHALATION RISK:
No indication can be given about the rate in which a harmful concentration in the air is reached on evaporation of this substance at 20°C.

EFFECTS OF SHORT-TERM EXPOSURE:
The substance is mildly irritating to the eyes and the skin .

EFFECTS OF LONG-TERM OR REPEATED EXPOSURE:
The liquid defats the skin.

PHYSICAL
PROPERTIES

Boiling point: 189°C
Melting point: -44°C
Relative density (water = 1): 0.91
Solubility in water:
very good
Vapour pressure, Pa at 20°C: 79

Relative vapour density (air = 1): 5.6
Relative density of the vapour/air-mixture at 20°C (air = 1): 1.0
Flash point: 71°C c.c.
Auto-ignition temperature: 174°C
Octanol/water partition coefficient as log Pow: 0.39

ENVIRONMENTAL
DATA

N O T E S

Health effects of exposure to the substance have not been investigated adequately for long-term effects. Check for peroxides prior to distillation; eliminate if found.

NFPA Code: H 1; F 2; R 0;

ADDITIONAL INFORMATION

ICSC: 1151	DIETHYLENE GLYCOL DIETHYL ETHER
(C) IPCS, CEC, 1994

IMPORTANT LEGAL NOTICE:

Neither NIOSH, the CEC or the IPCS nor any person acting on behalf of NIOSH, the CEC or the IPCS is responsible for the use which might be made of this information. This card contains the collective views of the IPCS Peer Review Committee and may not reflect in all cases all the detailed requirements included in national legislation on the subject. The user should verify compliance of the cards with the relevant legislation in the country of use. The only modifications made to produce the U.S. version is inclusion of the OSHA PELs, NIOSH RELs and NIOSH IDLH values.